WildWilly
New Member
More problems, I was driving yesterday and my truck lost ALL power and is smoking heavily. This is a whitish smoke and smells like raw fuel. I just filled up my tank and added one small bottle of lucas additive. My guess is an injector or two are sticking open or maybe a push rod has slipped off but the truck is not really missing, it just smokes bad and will only run about 10 MPH or maybe slower! It seems like I have done nothing but worked on this motor since I installed it. I am getting some air in the fuel lines and have tracked it down to where I need to pull the tank to fix but it was running fine until it started smoking and lost ALL power.
Demographics: tell us about your truck and your ambient conditions:
- Year: ___1993___
- Truck model and class (ie: c2500) ___GMC K3500______
- Automatic or Standard ____automatic______
- Mileage: (indicate miles or km) ___213,000 miles______
- Replaced parts and mods (IP, PMD, chip/PCM, TM, injectors etc) ____95 NA IP 1/2 turn_______
- Model: ‘S’ or ‘F’ engine, NA or Turbo, EGR? _____Turbo_________
- Ambient outside temp: (indicate *C or *F) _____70 F_____
- What fuel are you using? (#1 Diesel, #2 Diesel, Bio, VO, WVO, etc) ____#1_____
- What fuel additives are you using? ____Lucas oil_______
- Where are you located? _____Northern Kentucky________
General maintenance: inspect and evaluate the condition of each. When were they last changed?
- Air filter ___new______
- Fuel filter ____new_____
- CDR Valve? ____3 months old_____
- Coolant – last flushed/replaced at _____3 months ago________
- Oil – synthetic/regular, changed at _____regular just changed______
- Batteries – state of charge, (matched set) replaced at ____good_________
- Battery cables and grounds (removed, cleaned and tightened): _____yes_________
- Glow Plugs - how many miles on them? ____new_____ What type? _______AC delco______
- Injectors - last changed at ______?_________
History: (Describe how the problem first appeared.)
- What were you doing when it happened? ____pulling a hill with a small car trailer on the rear bumper__________
- How was the truck running fine before this problem appeared? _____running great________
- Has this problem ever happened before? ________no_______________
- Describe any related factors that might be part of the problem. ______getting some air in the fuel lines from the tank area________
- Have you checked for DTC (Diagnostic Trouble Codes)? (Y.N) _N___ And? ________
Diagnostics:
1] Starting:
1a] Does the engine start? ___YES______
1b] Does the engine crank over? ___YES_____
1c] Are your batteries fully charged? __YES_______
1d] Have you removed, cleaned, and tightened all battery connections? ___YES_____
1e] Does your Wait to Start light come on for a time? How long? ___Bypass______
1f] Does your glow plug light come on? __yes_______ For how long? ___10 seconds______
1g] Do you see smoke from the exhaust while cranking? What color? __no______
1h] Does the Service Engine Light Glow during Start/bulb check? __yes______
2] Fuel Issues (if not running):
2a] Can you hear your lift pump working? _____yes_______
2b] Do you get a steady flow of fuel from the water drain (T-handle) ? ____yes_____
2c] Loosen the inlet line from the IP – is fuel coming out (Lift Pump on)? ___yes________
2d] Loosen an injector line and crank the engine - does fuel come out? ___yes______
2e] Do you hear a vacuum (hiss) when you remove the fuel cap? ____yes_______
3] PMD / IP Issues
3a] Location of PMD (on pump, on intake, remote mounted) ___MANUAL IP________
3b] Condition of Extension harness (if used) Vendor or Homemade? _________
3c] Condition of grounds / ground wires to IP / PMD. Check Harness. _________
3d] PMD Make: ___________
3e] PMD Age: _____________
4] Stalling Issues
4a] Do you experience stalling only when hot? ___NO_________
4b] Does it stall under particular circumstances? (ie hit bump, or on accel) ______
4c] Does pouring cool water over the IP seem to help with restarting? _________
4d] Is stalling momentary (engine recovers)? _________
4e] Does SES light come on when engine hiccups? _________
4f] Does cruise control quit working when engine hiccups? ___________
4g] Does re-starting seem to reset engine, restoring cruise and power? _________
4h] Changes to dash lights or instruments during stalling events? ___________
5] Running Issues
5a] On cold start, does upper rad hose get hard before engine warms up? ___NO____
5b] Any bubbles or oil film in coolant overflow tank? __NO_____
5c] Any white slime on oil surfaces (dipstick, CDR, oil Fill cap)? ___NO_______
5d] Excessive white smoke from exhaust on cold start? ___NO______
5e] Excessive black smoke from exhaust under hard acceleration? ____NO______
6] Performance Issues
6a] Do you have gauges (boost, EGT) ? ____NO_______
6b] Maximum boost under load? ____________
6c] Have you added a performance PCM (reflash) or Chip? ______NO________
6d] Have you changed exhaust / downpipe / crossover? ______NO__________
6e] Wastegate – mechanical or vacuum (OEM)? ____mechanical OEM__________
7] Temperature-related Issues:
7a] Single or dual thermostats? ____________
7b] Have you replaced them lately? Manufacturer of replacements? _________
7c] Have you pulled and cleaned Radiator and coolers lately? ____________
7d] Have you replaced the fan clutch? Manufacturer of replacement? ________
7e] (winter) Have you tested your antifreeze? Good to what temp? __________
7f] (winter) Are you using a winter grille cover? ___________
List and describe any other factors which are not addressed in this checklist. We can’t see, hear, smell, or touch your truck, so the more descriptive information you can give, the more likely it is that somebody can assist you.
Demographics: tell us about your truck and your ambient conditions:
- Year: ___1993___
- Truck model and class (ie: c2500) ___GMC K3500______
- Automatic or Standard ____automatic______
- Mileage: (indicate miles or km) ___213,000 miles______
- Replaced parts and mods (IP, PMD, chip/PCM, TM, injectors etc) ____95 NA IP 1/2 turn_______
- Model: ‘S’ or ‘F’ engine, NA or Turbo, EGR? _____Turbo_________
- Ambient outside temp: (indicate *C or *F) _____70 F_____
- What fuel are you using? (#1 Diesel, #2 Diesel, Bio, VO, WVO, etc) ____#1_____
- What fuel additives are you using? ____Lucas oil_______
- Where are you located? _____Northern Kentucky________
General maintenance: inspect and evaluate the condition of each. When were they last changed?
- Air filter ___new______
- Fuel filter ____new_____
- CDR Valve? ____3 months old_____
- Coolant – last flushed/replaced at _____3 months ago________
- Oil – synthetic/regular, changed at _____regular just changed______
- Batteries – state of charge, (matched set) replaced at ____good_________
- Battery cables and grounds (removed, cleaned and tightened): _____yes_________
- Glow Plugs - how many miles on them? ____new_____ What type? _______AC delco______
- Injectors - last changed at ______?_________
History: (Describe how the problem first appeared.)
- What were you doing when it happened? ____pulling a hill with a small car trailer on the rear bumper__________
- How was the truck running fine before this problem appeared? _____running great________
- Has this problem ever happened before? ________no_______________
- Describe any related factors that might be part of the problem. ______getting some air in the fuel lines from the tank area________
- Have you checked for DTC (Diagnostic Trouble Codes)? (Y.N) _N___ And? ________
Diagnostics:
1] Starting:
1a] Does the engine start? ___YES______
1b] Does the engine crank over? ___YES_____
1c] Are your batteries fully charged? __YES_______
1d] Have you removed, cleaned, and tightened all battery connections? ___YES_____
1e] Does your Wait to Start light come on for a time? How long? ___Bypass______
1f] Does your glow plug light come on? __yes_______ For how long? ___10 seconds______
1g] Do you see smoke from the exhaust while cranking? What color? __no______
1h] Does the Service Engine Light Glow during Start/bulb check? __yes______
2] Fuel Issues (if not running):
2a] Can you hear your lift pump working? _____yes_______
2b] Do you get a steady flow of fuel from the water drain (T-handle) ? ____yes_____
2c] Loosen the inlet line from the IP – is fuel coming out (Lift Pump on)? ___yes________
2d] Loosen an injector line and crank the engine - does fuel come out? ___yes______
2e] Do you hear a vacuum (hiss) when you remove the fuel cap? ____yes_______
3] PMD / IP Issues
3a] Location of PMD (on pump, on intake, remote mounted) ___MANUAL IP________
3b] Condition of Extension harness (if used) Vendor or Homemade? _________
3c] Condition of grounds / ground wires to IP / PMD. Check Harness. _________
3d] PMD Make: ___________
3e] PMD Age: _____________
4] Stalling Issues
4a] Do you experience stalling only when hot? ___NO_________
4b] Does it stall under particular circumstances? (ie hit bump, or on accel) ______
4c] Does pouring cool water over the IP seem to help with restarting? _________
4d] Is stalling momentary (engine recovers)? _________
4e] Does SES light come on when engine hiccups? _________
4f] Does cruise control quit working when engine hiccups? ___________
4g] Does re-starting seem to reset engine, restoring cruise and power? _________
4h] Changes to dash lights or instruments during stalling events? ___________
5] Running Issues
5a] On cold start, does upper rad hose get hard before engine warms up? ___NO____
5b] Any bubbles or oil film in coolant overflow tank? __NO_____
5c] Any white slime on oil surfaces (dipstick, CDR, oil Fill cap)? ___NO_______
5d] Excessive white smoke from exhaust on cold start? ___NO______
5e] Excessive black smoke from exhaust under hard acceleration? ____NO______
6] Performance Issues
6a] Do you have gauges (boost, EGT) ? ____NO_______
6b] Maximum boost under load? ____________
6c] Have you added a performance PCM (reflash) or Chip? ______NO________
6d] Have you changed exhaust / downpipe / crossover? ______NO__________
6e] Wastegate – mechanical or vacuum (OEM)? ____mechanical OEM__________
7] Temperature-related Issues:
7a] Single or dual thermostats? ____________
7b] Have you replaced them lately? Manufacturer of replacements? _________
7c] Have you pulled and cleaned Radiator and coolers lately? ____________
7d] Have you replaced the fan clutch? Manufacturer of replacement? ________
7e] (winter) Have you tested your antifreeze? Good to what temp? __________
7f] (winter) Are you using a winter grille cover? ___________
List and describe any other factors which are not addressed in this checklist. We can’t see, hear, smell, or touch your truck, so the more descriptive information you can give, the more likely it is that somebody can assist you.