Bought a 94 GMC Jimmy S15 and the Blower Motor only works on Low/Medium, not High. ALL Fuses good as is the Fusible Link, NEW Resistor/Relay/Motor but NOT Switch, any ideas?
Has anyone ever reprogrammed a door remote? I bought a 94' GMC S15 Jimmy with power locks and it came with a remote that won't work even though it has new batteries. If the remote itself is bad can I reprogram a factory remote from my 94' Camaro which uses different remotes that came with the...
I purchased my truck in 2000, it is all Factory except for the following, IP was replaced back in 2005, the lift pump back in 2008 (with a fuel pressure gauge mounted under the hood which shows 6 psi at idle) the tank/sending unit/fuel lines and the PMD (with a number 9 resistor) on a Heat Sink...
Are preformed Brake Lines available for my 96 Sierra 2500? Mine have rusted out after 8 years from Plowing/Salting and I am horrible at bending lines. I have found a few places that sell kits ($200.00+) but I only need the left and right side that are clipped onto the rear axle housing. I would...
Has anyone replaced the driver side exhaust manifold while the engine is in the truck? Mine is rusted badly from 8 years of plowing snow/salting and it is now leaking where the crossover pipe meets the manifold. I had the crossover replaced about 6 years ago and the manifold bolts had to be...
Yesterday June 29th on my way to Ky Speedway my Passenger side rear Axle/Hub almost came off the truck, it is a 1996 14 Bolt Full Floater with 373 Gears and the G80 Limited Slip that I have had problems with before concerning the Seals that goes into the Hubs (both sides), I replace this Hub...
Replaced the Fuel and Return Lines from the Lift Pump to the Tank, now have rusty lines (from 8 years of Plowing and Salting) leaking to the Injection Pump, are these a "Dealer Item" or can I buy them anywhere? My local Chev Dealer got shut down by Obama and now I can't get Dealer parts at...
Just picked up a 2000 Kawasaki Prairie 400 4X4 from a friend for $500.00 who has owned it since new. He sold it to me because when you turn the gas on it leaks fuel out of a hose coming from the bottom fuel bowl on the carburetor and therefore it does not want to stay running. I am presuming it...
My 96 Sierra 2500 4X4 has a new problem. I replaced the Power Steering Pump (reman) and the Hydro Boost (reman)for the Brakes about 5 years ago but not any hoses or the Steering Box and now I am noticing my Steering get stiff and my Brake Pedal going to the floor, so I thought the Pump was going...
Anybody ever use a Dorman Products PMD? Their website says they have a Lifetime Warranty and D-Tech only has a 1 Year Warranty! I will NOT use another Stanadyne ever again, Grey in color or not! Thank You for all replies, Keith
Anybody ever have a problem with starter bolts breaking? One broke and I could not get it out of the block so I put a new one from the Dealer in with washers to shorten it about a 1/4 in. and now it is broken too! Any ideas on how to get the broken pieces out?
My electronic IP has failed again! I know because the last time it did the Service THROTTLE Soon light came on and while the truck stayed running, it had no response from the throttle pedal! When the PMD failed this past February, the Service ENGINE Soon light came on and it would not start. I...
Anybody have problems with their rear seals leaking? I replace my rear brakes almost every year, sometimes twice because of leaking seals! This is expensive and frustrating! 8600 GVW, 60003 rear axle, 14 bolt full floater with the 3 1/2 in shoes! I have tried all different deal manufacturers and...
6.5 Engine Diagnostic Troubleshooting Checklist
Copy and paste this checklist into a new post, then answer all the questions by typing in your data into the (red) blanks as indicated - click in the middle of the blank, start typing.
Problem: Explain your problem in concise language (ie...
I am getting a "rattling" noise from the front end of my truck and I think it is the Water Pump! It is the original from 1996. I use the truck for pulling a 16 ft. enclosed trailer for lawn care in the summer and plowing snow in the winter and I know I need to "upgrade" the whole cooling system...
Are electric trailer brakes self adjusting or should they be done manually on a weekly or monthly basis depending on how often the trailer is used? Southwest Express Lines Enclosed 7 X 16 trailer with 3000# axles used everyday for Landscaping hauling about 2500# of equipment! Thanks for ALL...
I posted a lot of things under the title Problem Still Happening! I have now REPLACED The LP, The PMD, The Fuel Filter and last The Fuel Tank! My tank had a lot of silver flakes of something that looks like the inside lining of the ORIGINAL Fuel Tank so I just bought a new one! I cleaned the...
Problem: Explain your problem in concise language (ie: Cranks but won’t fire). Runs o.k.,then starts stumbling and eventually quits. Does not make a difference if it is hot or cold, rain or shine. After sitting a while it will start back, run fine, then start the symptoms all over again...